Back to all

Such a Little Part (Climate Control Resistor)

November 22, 2020

You expect your heater/air conditioner to work like it should.  You have a control for temperature and one for fan speed.  You even have a control for what vents the air comes out of. 

Don't be surprised one day if your blower fan develops a mind of its own and starts going crazy.  Most of the time, you may find that it starts blowing at full speed, and nothing you do to try to control it does any good.  This is what may be happening.

Your blower motor has an electronic component called a resistor.  It does what its name says; it offers resistance.  When you want the fan to run more slowly, you turn the fan speed down.  That resistor accomplishes that by turning its resistance up.  When the resistor fails, the power has nothing to slow it and the fan speeds up. 

It's a small part and can fail due to age or corrosion.  It's usually not an expensive part, either, but it's often found in a location that's not that easy for the technician to get to.  That means labor costs will vary depending on the design of your vehicle. 

Occasionally, a faulty resistor can cause the blower motor not to work at all or only partially come on.  But other things can cause that as well, such as a faulty fan switch or vent control. 

This is where a technician's training comes in.  Special equipment can track down precisely where the issue is so you can be assured the correct part is being replaced.

It's just not pleasant when the blower motor isn't following orders.  Have your service facility check it out so you can be the blower's boss, like it should be. 

Tuffy Tire & Auto Service Aurora
3190 N. Aurora Rd.
Aurora, Illinois 60502
630-898-6688

More articles from Tuffy Aurora

3 Winter Windshield Tips (Care of Windshield)

July 6, 2025

Cold weather can present some real challenges when it comes to your vehicle's windshield. Think of it. Your windshield is your window to the world when you're driving, and clear visibility is extraordinarily important for safe travels. So here are 3 tips to ensure that your windshield can do it... More

The Third Brake Light (Third Brake Light Service)

June 29, 2025

So you thought you only had two brake lights. Look again and you'll see one in the center at a higher level than the two on either side of the vehicle. They're sometimes in the inside of the vehicle behind the back window, or they could be in the deck lid, on the roof or on the spare wheel carr... More

Taking the Heat (Batteries in Hot Weather)

June 22, 2025

Quick question. Which is tougher on a vehicle's battery, the heat or the cold? Believe it or not, it's the heat. Think about it. The battery often sits in the engine compartment next to that motor generating lots of heat. That can accelerate corrosion in the battery and may even cause water i... More